Gt4Driver

#1

Hi! First sorry my bad english.

But i need help with my st205

My car started to keep very awful wheezing noise. car works fine but the noise is something that i cant figure out.
i think it comes somewhere intake?

i hear it all the time when driving, but when i accelerate sound stops.?

maybe i need to get some video for that sound..

Gt4Driver

#2

http://s1209.photobucket.com/albums/cc400/...ajuttuja009.mp4

3WayStunna

#3

Sounds like metal on metal noise...could be wrong though....maybe someone else can chime in..

---

(\__/)(='.'=) This is bunny. Copy and paste bunny into your(")_(") signature to help him gain world domination.

nsxtypeR

#4

Check all the nuts that hold the intake-manifold. I've had exactly the same a while ago. Turned out to be a missing nut on the intake, the noise you hear is air.

---

JDM ST205

Gt4Driver

#5

yes it sounds like some air leak. have to check the nuts next. thanks for advice:)
i already check all the pipes i could see and they were ok.

Gt4Driver

#6

how can i check the nuts? do i have to remove engine before i can see them?
very narrow place

nsxtypeR

#7

Take a socket (i believe the nuts are size 12mm) with some extensions until you can reach the nuts. It's not easy to access them, the lower ones are best to do from underneath the car. You need patience for sure

---

JDM ST205

Gt4Driver

#8

good morning!
last night i check the nuts and tight them. did not help. the noise wont go off.
what should i do? im out of ideas.

Needles

#9

maybe one of the belt or idler pulley make that noise, just a suggestion, i never heard that sound before

3WayStunna

#10

Sounds like something metal vibrating at low rpms. Sound is annoying as all hell and i can understand why you would want to find out what it is...if i were you, i would go over anything i ever messed with before the sound started....if that brings you no results, then at least you have narrowed things down a bit.

Next think logically about what could of gone wrong to cause that noise...i mean it had to just happened right? Or has it been something you dealt with since you owned the car? Either way work from their AFTER you have checked over any and everything you have messed with before the noise started...

---

(\__/)(='.'=) This is bunny. Copy and paste bunny into your(")_(") signature to help him gain world domination.

delusionz

#11

sounds like the noise i had when my original ct20b bent the shaft and the compressor wheel was scraping the housing, the whole turbo unit was throw away..

ended up being worn bearings finally giving out cuz the oil feed was carboned up

---

Mike W1996 Toyota Celica ST205 GT-FOURGT2860RS turbine, TiAL mvr44, JE 86.5φ piston, Clutchmasters FX400, APEX P-FC269awhp / 273ft-lbs

cax_11

#12

check all air hoses, and every other piping that goes to the intake manifold, I'm almost certain its an airleak, the fact that it goes away when you hit the accelerator makes me think that, the air pressure changes when you press the gas causes the sound to go away, you can also use a plastic pipe to narrow down where the sound is coming from, the way your gonna do this is by, putting one end of the pipe to your ear and block off the other ear and move the other end of the hose around until you can hear the sound intensifying, it should put you directly ontop of the noise source and you can go on investigating from there.

---

1994 Toyota Celica GT-Four ST205 Turbo 4WD, BlackNevis, West Indies

Gt4Driver

#13

Hi! Could this be my solution?

one of my injector sealing looked like this. other three was ok. it´s not easy to remove the intake manifold. so maybe i just replace those gasgets.
what do you guys think?

playboymma

#14

that REALLY sounds like a vacuum leak

---

I went full retard once, too. Its OK.

Gt4Driver

#15

could this cause that?

Smaay

#16

thats exactly what the problem is. replace all 4 of those gaskets while you have the manifold off

---

2001 Celica GT-S Turbo1997 Supra TT 6speed1997 Celica 3MZ/1MZ swap1990 Celica All-Trac

Gt4Driver

#17

ok. yesterday i put new seals in and start putting parts together..
Today have to go to work, after that intercooler goes in and ready to start
ofcourse first new oils and coolant water.

Gt4Driver

#18

I start my car today and let it idle. The sound was gone..
After one or two minutes The ****ing noise started..

and i havent done the car anything else but installed boost controller. and i take it off yesterday. so the car is standard. except exhaust.

Gt4Driver

#19

ok. i have been searchin where that noise is coming from. and i think it comes somewhere under the distributor.
there is some pipes and next i replace those.
something that i noticed. when the motor is cold the noise is almos gone. but after couple minutes it jus get louder or if i touch the gas pedal.
all help you can give will be worthless.

Terracar

#20

that does sound metal on metal rotational contact. (like a bearing). Since I believe it is related to the compressor wheel and possible contact with housing or a bearing I would suggest this as a check...

When the engine is idling and making the noise, disconnect one of the couplers from the intercooler - effectively letting the turbo just blow to the atmosphere. If it stops, I would say it is turbo related.

Do not do this check while revving the engine or in a dusty location. Do no drive the car like this as this is only a diagnostic check.

-Terracar

---

'92 ST185, '88 ST165, '05 Galant LS, '08 Legacy

Gt4Driver

#21

no. it's not the turbo. i'm going to the toyota dealer saturday. and ask what they think it is.
I'm losing my mind with this...

delusionz

#22

yeah or stick your hand in there to hold the compressor while the motor is off

get your friend to start it up while you've got that held

---

Mike W1996 Toyota Celica ST205 GT-FOURGT2860RS turbine, TiAL mvr44, JE 86.5φ piston, Clutchmasters FX400, APEX P-FC269awhp / 273ft-lbs

nsxtypeR

#23

Like I said before, it's 100% an air leak. It sure is not a mechanical part like turbo or bearings.

---

JDM ST205

99gt3sge

#24

yeah it really sounds like an air leak, but it could be a bearing, possibly from distributor imo,

Gt4Driver

#25

Ok. my friend check my car, and says it's an air leak. so tomorrow i start to chance the intakemanifold gasget.

99gt3sge

#26

if your car still runs turn it on and spray carb cleaner on the intake side, and watch if it idles diffrent when the you spray it. thats another way to check b4 you take it apart.

Gt4Driver

#27

yeah. i already start to dismantle it. next weekend i get a new gasget.

Gt4Driver

#28

Hello everybody!
today i got my celica ready. and the noise is off
it was the intakemanifold gasget..
thank you all for helping me